Control of fracturing behavior of fractured reservoir under horizontal wells

WANG Zhi-rong; SONG Pei; WEN Zhen-yang; CHEN Ling-xia

doi:10.13374/j.issn2095-9389.2019.11.15.003

Volume 42 Issue 11

Nov. 2020

Turn off MathJax

Article Contents

Article Navigation > Chinese Journal of Engineering > 2020 > 42(11): 1449-1456

WANG Zhi-rong, SONG Pei, WEN Zhen-yang, CHEN Ling-xia. Control of fracturing behavior of fractured reservoir under horizontal wells[J]. Chinese Journal of Engineering, 2020, 42(11): 1449-1456. doi: 10.13374/j.issn2095-9389.2019.11.15.003

Citation:

WANG Zhi-rong, SONG Pei, WEN Zhen-yang, CHEN Ling-xia. Control of fracturing behavior of fractured reservoir under horizontal wells[J]. Chinese Journal of Engineering, 2020, 42(11): 1449-1456. doi: 10.13374/j.issn2095-9389.2019.11.15.003

Citation:

PDF( 886 KB)

Control of fracturing behavior of fractured reservoir under horizontal wells

doi: 10.13374/j.issn2095-9389.2019.11.15.003

School of Water Conservancy Engineering, Zhengzhou University, Zhengzhou 450001, China

More Information

Corresponding author: E-mail: wangzhirong513@sina.com
Received Date: 2019-11-15
Publish Date: 2020-11-25

Abstract

Abstract

There are many practical engineering problems in the hydraulic fracturing of crack reservoirs, such as the maintenance of wall rock, the efficiency of reservoir's permeability and the prevention of groundwater hazard. In this paper, the control mechanism of fracture pressure under multi-field and multi-phase coupling in horizontal wells and the fracturing evaluation of crack reservoirs were studied deeply to address these issues. Firstly, the transformation effect of the perforation concentration on the original stress field was analyzed. Secondly, the permeability of fracturing fluid in the primary fractures was considered. Finally, based on the strength principle of fracture mechanics, the calculation model of fracture pressure for horizontal wells in the reservoir was established. Furthermore, the influence of the spatial geometric parameters of the fracture field on the initiation pressure was analyzed, and the concept of the characteristic parameters of the fracture field was proposed. The results indicate that the coupling of fluid-solid multiphase in the fields of perforation stress, fracturing fluid permeation and original fracture leads to horizontal well hydraulic fracturing, and the characteristic parameter of fracture field plays a leading role in controlling the initiation pressure. Among them, the biggest controlling factor on initiation pressure is crack width. When the crack width of reservoir is within 200–700 μm, hydraulic fracturing has practical significance for improving reservoir permeability, which solves the problem about the quantification of initiation pressure and the fracturing evaluation in crack reservoirs. By calculating initiation pressure and contrasting to engineering example, it is found that the productivity of the sandstone reservoir is very ideal in the H8 section of the eastern Sulige gas field after hydraulic fracturing, and the theoretical value of fracture initiation pressure is in good agreement with the measured value, which verifies the correctness of the model. These can provide theoretical basis for fracturing construction of horizontal wells.
- horizontal well,
- many field and heterogeneous,
- cracking medium,
- cracking pressure,
- wide of fracture

FullText(HTML)

References(26)

References

[1]	崔峰, 劉星合. 綜采工作面水力壓裂頂板控制技術研究. 煤炭科學技術, 2019, 47(9):172 Cui F, Liu X H. Research on control technology of hydraulic fracturing roof in fully-mechanized mining face. Coal Sci Technol, 2019, 47(9): 172
[2]	張杰, 楊濤, 索永錄, 等. 基于耦合評價的安山煤礦頂板突水預測模型研究. 西安科技大學學報, 2018, 38(4):569 Zhang J, Yang T, Suo Y L, et al. Forecast model for roof water inrush in Anshan coal mine based on coupling evaluation. J Xi’an Univ Sci Technol, 2018, 38(4): 569
[3]	孫魁, 王英, 李成, 等. 巨厚煤層頂板離層水致災機理研究. 河南理工大學學報: 自然科學版, 2018, 37(2):14 Sun K, Wang Y, Li C, et al. Mechanism of roof separation water disaster in thick coal seam. J Henan Polytech Univ Nat Sci, 2018, 37(2): 14
[4]	張群, 葛春貴, 李偉, 等. 碎軟低滲煤層頂板水平井分段壓裂煤層氣高效抽采模式. 煤炭學報, 2018, 43(1):150 Zhang Q, Ge C G, Li W, et al. A new model and application of coalbed methane high efficiency production from broken soft and low permeable coal seam by roof strata-in horizontal well and staged hydraulic fracture. J China Coal Soc, 2018, 43(1): 150
[5]	Yin L M, Ma K, Chen J T, et al. Mechanical model on water inrush assessment related to deep mining above multiple aquifers. Mine Water Environ, 2019, 38(4): 827 doi: 10.1007/s10230-019-00623-3
[6]	巫修平, 張群. 碎軟低滲煤層頂板水平井分段壓裂裂縫擴展規律及控制機制. 天然氣地球科學, 2018, 29(2):268 Wu X P, Zhang Q. Research on controlling mechanism of fracture propagation of multi-stage hydraulic fracturing horizontal well in roof of broken soft and low permeability coal seam. Nat Gas Geosci, 2018, 29(2): 268
[7]	鄭綱, 徐小兵, 何淵, 等. 厚煤層放頂煤開采底板突水機理及水害探查技術. 煤田地質與勘探, 2019, 47(增刊1): 7 Zheng G, Xu X B, He Y, et al. Mechanism of Ordovician limestone water inrush from the floor of caving mining face in thick coal seam and water hazard detection technology of nearly horozontal borehole. Coal Geol Explor, 2019, 47(Suppl 1): 7
[8]	丁乙, 劉向君, 羅平亞. 裂縫性儲層射孔井起裂壓力影響因素分析. 應用數學和力學, 2018, 39(7):811 Ding Y, Liu X J, Luo P Y. Research on influential factors of initiation pressure in fracture formation for perforated boreholes. Appl Math Mech, 2018, 39(7): 811
[9]	范勇, 趙彥琳, 朱哲明, 等. 基于井筒-射孔模型的地層破裂壓力及起裂角的理論研究. 中南大學學報: 自然科學版, 2019, 50(3):669 Fan Y, Zhao Y L, Zhu Z M, et al. Theoretical study of break down pressures and fracture initiation angles based on model containing wellbore and perforations. J Cent South Univ Sci Technol, 2019, 50(3): 669
[10]	劉得潭, 沈振中, 徐力群, 等. 裂隙巖體水力劈裂臨界水壓力試驗研究. 南水北調與水利科技, 2018, 16(2):140 Liu D T, Shen Z Z, Xu L Q, et al. Experimental study on critical internal water pressure of hydraulic fracturing of fractured rock mass. South-to-North Water Transfers Water Sci Technol, 2018, 16(2): 140
[11]	鄧帥, 朱哲明, 王磊, 等. 原巖應力對裂紋動態斷裂行為的影響規律研究. 巖石力學與工程學報, 2019, 38(10):1989 Deng S, Zhu Z M, Wang L, et al. Study on the influence of in-situ stresses on dynamic fracture behaviors of cracks. Chin J Rock Mech Eng, 2019, 38(10): 1989
[12]	Lu Y, Li H T, Lu C, et al. Predicting the fracture initiation pressure for perforated water injection wells in fossil energy development. Int J Hydrogen Energy, 2019, 44(31): 16257 doi: 10.1016/j.ijhydene.2019.04.208
[13]	張帆, 馬耕, 劉曉, 等. 煤巖水力壓裂起裂壓力和裂縫擴展機制實驗研究. 煤田地質與勘探, 2017, 45(6):84 doi: 10.3969/j.issn.1001-1986.2017.06.014 Zhang F, Ma G, Liu X, et al. Experimental study on initiation pressure and mechanism of fracture propagation of hydraulic fracturing in coal and rock mass. Coal Geol Explor, 2017, 45(6): 84 doi: 10.3969/j.issn.1001-1986.2017.06.014
[14]	程玉剛, 盧義玉, 葛兆龍, 等. 孔隙水壓力梯度對煤層導向壓裂控制影響. 東北大學學報: 自然科學版, 2017, 38(7):1043 Cheng Y G, Lu Y Y, Ge Z L, et al. Influence of pore water pressure gradient on guiding hydraulic fracturing in underground coal mine. J Northeast Univ Nat Sci, 2017, 38(7): 1043
[15]	馬天壽, 彭念, 陳平, 等. 頁巖氣水平井井壁裂縫起裂力學行為研究. 西南石油大學學報: 自然科學版, 2019, 41(6):87 Ma T S, Peng N, Chen P, et al. Wellbore fracture initiation mechanical behavior in a horizontal shale gas well. J Southwest Petrol Univ Sci Technol Ed, 2019, 41(6): 87
[16]	文賢利. 水力噴射壓裂裂縫起裂與擴展規律研究[學位論文]. 西安: 西安石油大學, 2011 Wen X L. Study on the Fracture Initiation and Propagation for Hydrajet-Fracturing[Dissertation]. Xi’an: Xi’an Shiyou University, 2011
[17]	張金才, 尹尚先. 頁巖油氣與煤層氣開發的巖石力學與壓裂關鍵技術. 煤炭學報, 2014, 39(8):1691 Zhang J C, Yin S X. Some technologies of rock mechanics applications and hydraulic fracturing in shale oil, shale gas and coalbed methane. J China Coal Soc, 2014, 39(8): 1691
[18]	李丹瓊, 張士誠, 張遂安, 等. 基于煤系滲透率各向異性測試的水平井穿層壓裂效果模擬. 石油學報, 2015, 36(8):988 doi: 10.7623/syxb201508010 Li D Q, Zhang S C, Zhang S A, et al. Effect simulation of horizontal well fracturing through strata based on coal seam permeability anisotropy test. Acta Petrol Sin, 2015, 36(8): 988 doi: 10.7623/syxb201508010
[19]	詹美禮, 岑建. 巖體水力劈裂機制圓筒模型試驗及解析理論研究. 巖石力學與工程學報, 2007, 26(6):1173 doi: 10.3321/j.issn:1000-6915.2007.06.011 Zhan M L, Cen J. Experimental and analytical study on hydraulic fracturing of cylinder sample. Chin J Rock Mech Eng, 2007, 26(6): 1173 doi: 10.3321/j.issn:1000-6915.2007.06.011
[20]	程靳, 趙樹山. 斷裂力學. 北京: 科學出版社, 2006 Cheng J, Zhao S S. Fracture Mechanics. Beijing: Science Press, 2006
[21]	李宏欣. 焦作九里山井田煤層氣賦存特征分析. 中州煤炭, 2012, 34(9):4 doi: 10.3969/j.issn.1003-0506.2012.09.002 Li H X. Analysis on CBM occurrence characteristics of Jiulishan coalfield in Jiaozuo. Zhongzhou Coal, 2012, 34(9): 4 doi: 10.3969/j.issn.1003-0506.2012.09.002
[22]	葉建平, 張守仁, 凌標燦, 等. 煤層氣物性參數隨埋深變化規律研究. 煤炭科學技術, 2014, 42(6):35 Ye J P, Zhang S R, Ling B C, et al. Study on variation law of coalbed methane physical property parameters with seam depth. Coal Sci Technol, 2014, 42(6): 35
[23]	馬旭, 郝瑞芬, 來軒昂, 等. 蘇里格氣田致密砂巖氣藏水平井體積壓裂礦場試驗. 石油勘探與開發, 2014, 41(6):742 doi: 10.11698/PED.2014.06.15 Ma X, Hao R F, Lai X A, et al. Field test of volume fracturing for horizontal wells in Sulige tight sandstone gas reservoirs. Petrol Explor Dev, 2014, 41(6): 742 doi: 10.11698/PED.2014.06.15
[24]	崔明明, 李進步, 王宗秀, 等. 辮狀河三角洲前緣致密砂巖儲層特征及優質儲層控制因素——以蘇里格氣田西南部石盒子組8段為例. 石油學報, 2019, 40(3):279 doi: 10.7623/syxb201903003 Cui M M, Li J B, Wang Z X, et al. Characteristics of tight sand reservoir and controlling factors of high-quality reservoir at braided delta front: a case study from Member 8 of Shihezi formation in southwestern Sulige gas field. Acta Petrol Sin, 2019, 40(3): 279 doi: 10.7623/syxb201903003
[25]	鄧華鋒, 朱敏, 李建林, 等. 砂巖I型斷裂韌度及其與強度參數的相關性研究. 巖土力學, 2012, 33(12):3585 Deng H F, Zhu M, Li J L, et al. Study of mode-Ⅰ fracture toughness and its correlation with strength parameters of sandstone. Rock Soil Mech, 2012, 33(12): 3585
[26]	周文露. 蘇里格東區召54井區馬五_(1-4)亞段沉積與成巖作用研究[學位論文]. 成都: 西南石油大學, 2016 Zhou W L. Sedimentary and Diagenesis of Mawu _ (1-4) Subsection in Well Zhao54, Sulige District[Dissertation]. Chengdu: Southwest Petroleum University, 2016