Preparation of polyurethanes with broad temperature range and high damping factor

LU Xun; XU Min; LI Zhi-peng; LI Han-mo; ZHUANG Wen-hui

doi:10.13374/j.issn2095-9389.2019.04.12.006

Volume 42 Issue 3

Mar. 2020

Turn off MathJax

Article Contents

Article Navigation > Chinese Journal of Engineering > 2020 > 42(3): 365-371

LU Xun, XU Min, LI Zhi-peng, LI Han-mo, ZHUANG Wen-hui. Preparation of polyurethanes with broad temperature range and high damping factor[J]. Chinese Journal of Engineering, 2020, 42(3): 365-371. doi: 10.13374/j.issn2095-9389.2019.04.12.006

Citation:

LU Xun, XU Min, LI Zhi-peng, LI Han-mo, ZHUANG Wen-hui. Preparation of polyurethanes with broad temperature range and high damping factor[J]. Chinese Journal of Engineering, 2020, 42(3): 365-371. doi: 10.13374/j.issn2095-9389.2019.04.12.006

Citation:

PDF( 1063 KB)

Preparation of polyurethanes with broad temperature range and high damping factor

doi: 10.13374/j.issn2095-9389.2019.04.12.006

1.
School of Materials Science and Engineering, South China University of Technology, Guangzhou 510640, China
2.
Guangzhou Huagong Motor Vehicle Inspection Technology Co., LTD, Guangzhou 510640, China

More Information

Corresponding author: E-mail: whzhuang@scut.edu.cn
Received Date: 2019-04-12
Publish Date: 2020-03-01

Abstract

Abstract

The continuous improvement of people’s living standards and quality puts higher and higher demands on polymer materials, and damping materials such as polyurethane elastomer used for vibration and noise reduction have also received increasing attention. However, the application of polyurethanes is limited to some extent owing to the narrow effective damping temperature range of polyurethane. Therefore, polyurethane containing a branched chain has been prepared from the perspective of its structural designability, in which the prepolymer synthesized by the reaction of polyethylene glycol monomethyl ether (MPEG) with toluene 2,4-diisocyanate (TDI) is performed as a branched chain. Herein, the long branched chain with one end fixed at the end gives its unique movement and relaxation, contributing to the superior damping performance of polyurethane to some extent, and the presence of TDI not only prolongs the length of the branch and increases the entanglement degree between the branches and the molecules but also makes the branches contain a strong polar electron-withdrawing isocyanate group and a urethane group, impacting the branch and the main chain with strong hydrogen bonding effect. Herein, the influencing factors of polyurethane on damping property are explored separately from the perspective of hydrogen bonding and microphase separation. By means of Fourier transform infrared spectroscopy (FTIR), dynamic mechanical analysis (DMA), atomic force microscopy (AFM), and broadband dielectric relaxation spectroscopy, the results show that E'_{30 °C}/E'_{70 °C} is able to reach 268.28 with the increased proportion of branches, indicating the dropped degree of microphase separation of polyurethanes. Furthermore, the hydrogen bonding effect is enhanced by characterization with FTIR. The two aforementioned effects make the damping properties of polyurethanes more excellent; the effective damping (tan δ ≥ 0.3) can even exceed 150 °C (?50?100 °C). Simultaneously, the polyurethane has a certain self-healing property after the introduction of branches, which is of great significance to extend the service life of polyurethanes
- damping,
- long branched chain,
- polyurethane,
- self-healing,
- hydrogen bonding,
- microphase separation

FullText(HTML)

References(24)

References

[1]	肖玉蘭, 王俊彪, 楊志鵬, 等. 阻尼車輪減振參量的有限元仿真與優化設計. 噪聲與振動控制, 2018, 38(3):83 doi: 10.3969/j.issn.1006-1355.2018.03.015 Xiao Y L, Wang J B, Yang Z P, et al. Finite element simulation and optimization design of the parameters of vibration reduction for damped wheels. Noise Vib Control, 2018, 38(3): 83 doi: 10.3969/j.issn.1006-1355.2018.03.015
[2]	李斌, 楊麗博, 張保生, 等. 高分子阻尼材料的制備及其在橋梁支座上的應用. 世界橡膠工業, 2017, 44(3):40 doi: 10.3969/j.issn.1671-8232.2017.03.015 Li B, Yang L B, Zhang B S, et al. Preparation of damping materials and its engineer applications on bridge bearing. World Rubber Ind, 2017, 44(3): 40 doi: 10.3969/j.issn.1671-8232.2017.03.015
[3]	Sun Y F, Gong J, Liu Y, et al. Viscous, damping, and mechanical properties of epoxy asphalt adhesives containing different penetration-grade asphalts. J Appl Polym Sci, 2019, 136(5): 47027 doi: 10.1002/app.47027
[4]	牛文, 唐德密. 聚合物改性砂漿修補材料阻尼特性及微觀機理研究. 施工技術, 2017, 46(15):85 Niu W, Tang D M. Study on damping characteristics and microscopic mechanism of polymer modified mortar repair material. Constr Technol, 2017, 46(15): 85
[5]	Shi M X, Zheng J L, Huang Z X, et al. Synthesis of polyurethane pre-polymers and damping property of polyurethane/epoxy composites. Adv Sci Lett, 2011, 4(3): 740 doi: 10.1166/asl.2011.1597
[6]	Kumar D, Kumar N, Jindal P. Effect of MWCNTs on damping behavior of polyurethane based nanocomposites. Mater Today Proc, 2018, 5(2): 5636 doi: 10.1016/j.matpr.2017.12.156
[7]	李翰模, 楊一林, 李志鵬, 等. 基于網絡結構設計制備寬溫域高阻尼聚氨酯彈性體. 高分子材料科學與工程, 2017, 33(6):146 Li H M, Yang Y L, Li Z P, et al. Preparation of high damping polyurethane with wide temperature range based on network structure designing. Polym Mater Sci Eng, 2017, 33(6): 146
[8]	閆曉琦, 尹朝輝, 羅順, 等. 聚氨酯阻尼材料的研究進展. 中國膠粘劑, 2018, 27(4):46 Yan X Q, Yin Z H, Luo S, et al. Research progress of polyurethane damping materials. China Adhes, 2018, 27(4): 46
[9]	Lee K S, Choi J I, Kim S K, et al. Damping and mechanical properties of composite composed of polyurethane matrix and preplaced aggregates. Constr Build Mater, 2017, 145: 68 doi: 10.1016/j.conbuildmat.2017.03.233
[10]	Kim J M, Kim D H, Kim J, et al. Effect of graphene on the sound damping properties of flexible polyurethane foams. Macromol Res, 2017, 25(2): 190 doi: 10.1007/s13233-017-5017-9
[11]	Yu W W, Du M, Ye W J, et al. Relaxation behavior of layered double hydroxides filled dangling chain-based polyurethane/polymethyl methacrylate nanocomposites. Polymer, 2014, 55(10): 2455 doi: 10.1016/j.polymer.2014.03.039
[12]	Zhou R, Gao W Q, Xia L C, et al. The study of damping property and mechanism of thermoplastic polyurethane/phenolic resin through a combined experiment and molecular dynamics simulation. J Mater Sci, 2018, 53(12): 9350 doi: 10.1007/s10853-018-2218-3
[13]	Kausar A. Interpenetrating polymer network and nanocomposite IPN of polyurethane/ epoxy: a review on fundamentals and advancements. Polym-Plast Technol Mater, 2019, 58(7): 691 doi: 10.1080/25740881.2018.1563114
[14]	Yu W W, Zhang D Z, Du M, et al. Role of graded length side chains up to 18 carbons in length on the damping behavior of polyurethane/epoxy interpenetrating polymer networks. Eur Polym J, 2013, 49(6): 1731 doi: 10.1016/j.eurpolymj.2013.03.024
[15]	朱耀東, 賀國文, 李衡峰, 等. 聚氨酯彈性體的改性及阻尼性能. 功能材料, 2014, 45(21):21006 doi: 10.3969/j.issn.1001-9731.2014.21.002 Zhu Y D, He G W, Li H F, et al. Modification and damping performance of the polyurethane elastomers. J Funct Mater, 2014, 45(21): 21006 doi: 10.3969/j.issn.1001-9731.2014.21.002
[16]	Yu W W, Du M, Zhang D Z, et al. Influence of dangling chains on molecular dynamics of polyurethanes. Macromolecules, 2013, 46(18): 7341 doi: 10.1021/ma401260d
[17]	Lee H S, Wang Y K, Hsu S L. Spectroscopic analysis of phase separation behavior of model polyurethanes. Macromolecules, 1987, 20(9): 2089 doi: 10.1021/ma00175a008
[18]	Xu K M, Zhang F S, Zhang X L, et al. Molecular insights into hydrogen bonds in polyurethane/ hindered phenol hybrids: evolution and relationship with damping properties. J Mater Chem A, 2014, 2(22): 8545 doi: 10.1039/C4TA00476K
[19]	Zhou J H, Li H M, Lu X. Damping elastomer with broad temperature range based on irregular networks containing hyperbranched polyester and dangling chains. Polym Adv Technol, 2018, 29(8): 2308 doi: 10.1002/pat.4342
[20]	任龍芳, 陳婷, 強濤濤, 等. 超支化聚氨酯/聚氨酯共混膜的制備及其性能研究. 陜西科技大學學報:自然科學版, 2016, 34(1):11 Ren L F, Chen T, Qiang T T, et al. Study on the preparation and properties of HBPU/PU blend films. J Shaanxi Univ Sci Technol Nat Sci Ed, 2016, 34(1): 11
[21]	Castagna A M, Wang W Q, Winey K I, et al. Structure and dynamics of zinc-neutralized sulfonated polystyrene ionomers. Macromolecules, 2011, 44(8): 2791 doi: 10.1021/ma2001614
[22]	姚克儉. 改性蒙脫土/聚氨酯復合材料表面性能研究. 聚氨酯工業, 2018, 33(3):10 doi: 10.3969/j.issn.1005-1902.2018.03.003 Yao K J. Study on surface performance of modified montmorillonite/polyurethane composites. Polyurethane Ind, 2018, 33(3): 10 doi: 10.3969/j.issn.1005-1902.2018.03.003
[23]	Castagna A M, Pangon A, Choi T, et al. The role of soft segment molecular weight on microphase separation and dynamics of bulk polymerized polyureas. Macromolecules, 2012, 45(20): 8438 doi: 10.1021/ma3016568
[24]	田丹丹, 呂志平, 吳怡康, 等. 聚氨酯/甘氨酸-氯化鋇半有機晶體復合材料的制備與性能. 高分子材料科學與工程, 2016, 32(7):136 Tian D D, Lv Z P, Wu Y K, et al. Preparation and properties of polyurethane/glycine-barium chloride semiorganic crystal composites. Polym Mater Sci Eng, 2016, 32(7): 136