Competitive adsorption mechanism of organic depressant SDD with BX on copper-activated sphalerite

LUO De-qiang; LIU Jian; WANG Yu; ZENG Yong

doi:10.13374/j.issn2095-9389.2018.05.003

Volume 40 Issue 5

May 2018

Turn off MathJax

Article Contents

Article Navigation > Chinese Journal of Engineering > 2018 > 40(5): 540-547

LUO De-qiang, LIU Jian, WANG Yu, ZENG Yong. Competitive adsorption mechanism of organic depressant SDD with BX on copper-activated sphalerite[J]. Chinese Journal of Engineering, 2018, 40(5): 540-547. doi: 10.13374/j.issn2095-9389.2018.05.003

Citation:

LUO De-qiang, LIU Jian, WANG Yu, ZENG Yong. Competitive adsorption mechanism of organic depressant SDD with BX on copper-activated sphalerite[J]. Chinese Journal of Engineering, 2018, 40(5): 540-547. doi: 10.13374/j.issn2095-9389.2018.05.003

Citation:

PDF( 4568 KB)

Competitive adsorption mechanism of organic depressant SDD with BX on copper-activated sphalerite

doi: 10.13374/j.issn2095-9389.2018.05.003

LUO De-qiang¹,
LIU Jian^{1,2
,
,},
WANG Yu¹,
ZENG Yong²

1) Faculty of Land Resource Engineering, Kunming University of Science and Technology, Kunming 650093, China
2) State Key Laboratory of Complex Nonferrous Metal Resources Clean Utilization, Kunming University of Science and Technology, Kunming 650093, China

Received Date: 2017-09-19

Abstract

Abstract

The separation of Cu-Zn polymetallic sulfide by flotation has been a difficult and well-researched topic in the field of mineral processing. One of the important reasons why it is difficult to separate Cu and Zn is the presence of a large amount of copper ions in the pulp, which results in the unavoidable activation of sphalerite. The key to solving this difficulty is the development of a high-selectivity depressor for sphalerite. Sodium dimethyl dithiocarbamate (SDD, C₃H₆NS₂Na) is the lowest homologue of dialkyldithiocarbamate salts, and it has the shortest hydrophobic group (-CH₃) in its molecular structure with weak hydrophobicity. In preliminary exploration experiments, it was found that SDD has good selectivity for Cu-Zn sulfide flotation and can achieve better separation performance than conventional depressors. However, the depression mechanism is not very clear. In this work, the depression effect of SDD on copper-activated sphalerite was revealed by conducting a monomineral flotation test. Based on the results of this test, the competitive adsorption mechanism of SDD and BX on the surface of copper-activated sphalerite was further studied by conducting the Zeta potential test, LEIS (local AC impedance) test of Versa STAT electrochemical workstation, and frontal orbital theory calculation. The flotation results show that the SDD can effectively act as a depressant in copper-zinc separation. Sphalerite is depressed effectively in the presence of SDD, while chalcopyrite is not depressed. In addition, SDD has the characteristics of small dosage and high sensitivity. Under the optimum conditions with pH of 10 and SDD dosage of 4.0×10^-5 mol·L^-1, the recovery of copper-activated sphalerite can be reduced to 16.59%, while the recovery of chalcopyrite is 81.64%. Analysis of the results of the Zeta potential test and LEIS show that SDD can not only occupy the activation site of copper-activated sphalerite surface but also afford better adsorption capacity than BX, which greatly reduces the adsorption of BX on the surface of sphalerite. As a result, SDD shows a good depression effect for copper-activated sphalerite. The frontier orbital calculations further confirm that SDD is superior to BX in its ability to interact with minerals.
- copper-activated sphalerite,
- sodium dimethyl dithiocarbamate,
- competitive adsorption,
- local AC impedance,
- frontal orbital theory

FullText(HTML)

References(12)

References

[1]	Jiao F, Qin W Q, Liu R Z, et al. Adsorption mechanism of 2-mercaptobenzothiazole on chalcopyrite and sphalerite surfaces:Ab initio, and spectroscopy studies. Trans Nonferrous Met Soc China, 2015, 25(7):2388
[4]	Liu J, Wen S M, Deng J S, et al. DFT study of ethyl xanthate interaction with sphalerite (110) surface in the absence and presence of copper. Appl Surf Sci, 2014, 311:258
[5]	Liu J, Wen S M, Chen X M, et al. DFT computation of Cu adsorption on the S atoms of sphalerite (110) surface. Miner Eng, 2013, 46-47:1
[6]	Porento M, Hirva P. Effect of copper atoms on the adsorption of ethyl xanthate on a sphalerite surface. Surf Sci, 2005, 576(1-3):98
[7]	Ekmekçi Z, Aslan A, Hassoy H. Effects of EDTA on selective flotation of sulphide minerals. Physicochem Problems Miner Process, 2004, 38:79
[8]	Huang P, Cao M L, Liu Q. Selective depression of sphalerite by chitosan in differential Pb/Zn flotation. Int J Miner Process, 2013, 122:29
[10]	Qin W Q, Jiao F, Sun W, et al. Effects of sodium salt of N, N-dimethyldi-thiocarbamate on floatability of chalcopyrite, sphalerite, marmatite and its adsorption properties. Colloids Surf A:Physicochem Eng Aspects, 2013, 421:181
[14]	Jin T Y, Cheng Y F. In situ characterization by localized electrochemical impedance spectroscopy of the electrochemical activity of microscopic inclusions in an X100 steel. Corros Sci, 2011, 53(2):850
[15]	Long X H, Chen J H, Chen Y. Adsorption of ethyl xanthate on ZnS(110) surface in the presence of water molecules:a DFT study. Appl Surf Sci, 2016, 370:11
[16]	Long X H, Chen Y, Chen J H, et al. The effect of water molecules on the thiol collector interaction on the galena (PbS) and sphalerite (ZnS) surfaces:a DFT study. Appl Surf Sci, 2016, 389:103
[18]	Wang J Y, Liu Q X, Zeng H B. Understanding copper activation and xanthate adsorption on sphalerite by time-of-flight secondary ion mass spectrometry, X-ray photoelectron spectroscopy, and in situ scanning electrochemical microscopy. J Phys Chem C, 2013, 117(39):20089
[19]	Fukui K, Yonezawa T, Nagata C, et al. Molecular orbital theory of orientation in aromatic, heteroaromatic, and other conjugated molecules. J Chem Phys, 1954, 22(8):1433